Sump Pump Issues

Today's basement issue is the sump pump outside the basement door. It has been running at odd times and is increasingly noisy and vibrate-y. Since it hasn't been raining, I finally went to investigate, and sure enough, the pump seems like it's running dry, which is very bad for pumps.

The sump is a 12 x 12 x 12 box in the concrete landing. It also accepts drainage from a pipe coming from under the deck. The box and the grate on top of it are plastic, but it seems in fine condition.

The pump is a 1/3-HP cast-iron submersible sump pump made by Utilitech. It has a 120V wire going into the top of it, and another 120V wire that ends in a float thing. The powered float seems odd to me. Both wires run under the basement door and plug in to an ordinary outlet behind the door. A flexible hose connects to the 1-1/2 NPT discharge on the pump, allowing it to be pulled out of the sump. From there, it connects to a rigid pipe with a backflow preventer and a rigid pipe to drain that runs under the deck and daylights on the bank.

Update: I found an older model that looks like mine, with two 120V wires. The trick is, you have to plug the pump into the float switch plug, which is one of those "through" plugs. Obviously, the float switch interrupts power to the pump, except when the water is high enough.

First inspection showed 3 or 4 inches of debris in the sump and the float was resting on the debris. I cleaned that out, reassembled the kit, and now the pump doesn't want to shut off. The internet thinks that float valves go bad every four years or so.

I don't know when the pump got plugged in to the normal outlet, but perhaps it has been running that way for a week (since the water heater installation) and it only turns off when the motor gets too hot. Or maybe I plugged it in wrong when I started investigating and now its burned out because of me.

Maybe it's time for a new pump.

Home Depot offers one from Wayne for $120. This model, also from Wayne, features a "tether float switch" that looks more like the Utilitech model. It is $128.

Lowe's sells a newer Utilitech model for $99. It seems to have a 120V wire going to the float, but just a single wire going to the outlet.

Amazon sells Wayne and other brands, but not Utilitech. I liked this Liberty Pump because it's smaller and seems to have a more reliable float. It's $133.

Water Heater Installed

Thanks to Johnathan Jones, the water heater problems are history. I found the model I wanted online and the local Home Depot had 8 in stock. It had to be a Medium, not a Tall, or we would have needed to modify the hot and cold pipes. We bought the thing for around $610, carried it home (it's 127 pounds in the box) and hand-trucked it down the basement stairs. Draining the old tank added considerably to the water in the basement, but the sump pump at the door did its job. John made disconnecting the water and power look easy.

We wrestled the old tank toward the door, unpacked and wrestled the new one onto an insulated base (styrofoam) in a special plastic pan made for this purpose, and John made hooking it up look easy. We had to run to Home Depot for some ground wire and a ground clamp, but the new unit was quickly up and serving hot water.

The white PVC directs the pressure relief valve output to the floor (there's a drain to the right)

The next morning, the floor was largely dry. I installed the leak detector in the pan and the special WiFi module. It wouldn't let me set it up, so after three tries I contacted Rheem tech support. To my delight, they got back to me pretty quickly with alternate instructions involving my laptop. That worked, and my phone can now switch the water heater to vacation mode from anywhere in the world.

Model: Rheem XE50M12EC55U1W
Serial: M071709451
Manufactured: 2/13/2017
Bought/Installed: 3/22/2017
Electrical: 240V, dual 5500-watt elements
Warranty: 12 years parts / 3 years in home labor (warranty ends in 2029)

The owner's manual says to pull the anode every year and check it.

Comparable With Healthy Asking Price

Update 5/27/17: Went pending 3/25/17, fell out of contract, listing removed 5/4/17.

This just on the market, asking a full 18% over the Zestimate. $365/SF.

11502 4th Ave NW, Seattle, WA 98177

3 BR, 2 BA, 1970 SF. Hardwood floors throughout main level. One bed and bath on the lower floor. Oil furnace. New 40-year roof with "slick no maintenance gutters." Baths: one full, one 3/4. Lot size 10,018 SF. Built in 1951. Zestimate $610,059. Asking $719,900. (Originally, they asked $739,900, but came down $20 after ten days on Zillow.)

Not much Carkeek, if any, but it's at the end of a dead end street. That's 3rd Ave in the background of the photo--easy walk to the bus stop.

My Zestimate, today, is $669,648. 18% more would be $790,185. I'm 3 BR, 3 BA, 1592 SF. Lot size 10,798 SF. Built in 1947. I'm farther from the bus, but Carkeek is right there.

Unrepentant kitchen

Looks like the full bath is downstairs, the 3/4 bath is upstairs

One-car garage, but it is generous for a shop or storage

Not exactly a Sound view, but its better than mine.

Water Heater Issues

The water heater leaks. It still delivers hot water for showers, etc., but the city just billed me for 3x the water use over the same period last year. Not to mention the electricity for heating the water dribbling out.

Current is a Whirlpool EE2H50RD045V, 50-gal 240V 4500/4500. Installed 9/2003 (13.5 years ago) with a 9 year warranty. Serial number 0340103969 (who cares?). The Energy Guide sticker says that it uses 4772 kwh/Year.

I can replace it with models costing less than $500, and it looks like a pretty easy swap out. There's a handy cold water shut off right at the tank. Here's a spreadsheet of the available models.

The water heater has been leaking for some time, it seems--since January 2017 at least.

Aurora Plumbing was just here and gave me a bid of $1700 for a 10-year warranty Rheem, plus another $500 for labor. Or, for $750, they'll install a customer-supplied model. That's kind of nuts, since the model I like is the

Rheem Performance Platinum 50 Gal. Tall 12 Year 5500/5500-Watt Elements Electric Water Heater with Wi-Fi Module Included for $609, available at my local Home Depot. (The existing model is a Medium, meaning shorter; this is a Tall). 12 warranty on tank and parts, 3 year in home labor warranty. Dual 5500-watt stainless steel heating elements. EcoNet WiFi built-in.

Rheem XE50T12EC55U1W Performance Platinum 12-year warranty water heater.